1. Home
  2. Experimental Investigations On Replacement Of Sand By Quarry Dust In Concrete

Experimental Investigations On Replacement Of Sand By Quarry Dust In Concrete

  • Use Of Quarry Dust To Replace Sand In Concrete An

    III. EXPERIMENTAL INVESTIGATION A. Mix proportioning Two grades of concrete M20 and M25 having nominal mix proportion of 11.53 and 112 respectively were used by weight and wc ratio was fixed according to the slump requirement of 60mm. For this concrete mix quarry dust was added for replacement of sand from 0 to 100 in step of 10.

  • Pdf Use Of Quarry Dust To Replace Sand In Concrete An

    A. Mix proportioningTwo grades of concrete M20 and M25 having nominal mix proportion of 11.53 and 112 respectively were used by weight and wc ratio was fixed according to the slump requirement of 60mm. For this concrete mix quarry dust was added for replacement of sand

  • Experimental Investigation On Self Compacting Concrete

    Abstract This study presents an experimental investigation on self-compacting concrete SCC with fine aggregate sand replacement of a Quarry Dust QD 0 25 50 75 100 and addition of mineral admixtures like Fly Ash FA and Silica Fume SF amp

  • Experimental Study On Replacement Of Fine Aggregate In

    Dec 01 2019 Concrete mixes with quarry dust Mix-C Mix-AC amp Mix-BC showing lower strength values in all curing conditions. It found that the most suitable one to replace river sand is M-sand. Compared to the river sand the M-sand has a better quality.

  • Partial Replacement Of Sand By Quarry Dust In

    concrete on partial replacement of sand by Quarry dust. This Experimental Study is applicable not only for Box Culverts but any other concrete works as well. 7. CONCLUSION From the experiment result it is concluded that the use of Quarry dust as fine aggregate gives better result in compressive strength.

  • An Experimental Investigation On Properties Of Concrete By

    An Experimental Investigation on Properties of Concrete by Partial Replacement of Cement with GGBS and Fine Aggregate with Quarry Dust Dr. D. V. Prasada Rao C. S. Mallikarjuna In the present study an investigation is made on properties of concrete by partial replacement of Cement with Ground Granulated Blast Furnace Slag GGBS and Fine Aggregate with Quarry Dust QD.

  • Experimental Investigation On Quarry Dust As A Partial

    Experimental Investigation on Quarry Dust as a Partial Replacement of Sand for M-40 Grade Concrete Raju 1Jadham Anant Bharadwaj2 Siddharth 3Pastariya 1M.Tech Scholar Department of Civil Engineering Sri Aurobindo Institute of Technology Indore M.P

  • An Experimental Study On Uses Of Quarry Dust To

    An Experimental study on uses of Quarry Dust to replace sand in concrete Naushad Khan1 Ruchi Chandrakar2 1M.Tech Studenet Civil Engineering Dept Kalinga University New Raipur C.G. India 2Asst Professor Civil Engineering Dept Kalinga University New Raipur C.G. India

  • Pdf An Experimental Study On Effects Of Quarry Dust As

    Discussion on Result Result of Compressive Strength Test Result of Compaction Factor Test CONCLUSIONAll the results and data shows that the quarry dust is a suitable for alternative of natural sand in concrete.The results of compressive strength test shows that 50 replacement of sand by quarry dust gives higher value of compressive strength and 100 replacement of sand by quarry dust also

  • Experimental Study On Replacement Of Fine Aggregate In

    Dec 01 2019 In all curing conditions Compression and tensile strength of concrete with M-sand are on par with conventional natural sand concrete. Concrete mixes with quarry dust Mix-C Mix-AC amp Mix-BC showing lower strength values in all curing conditions. It found that the most suitable one to replace river sand is M-sand.

  • Pdf Use Of Quarry Dust To Replace Sand In Concrete An

    This experimental study presents the variation in the strength of concrete when replacing sand by quarry dust from 0 to 100 in steps of 10. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature.

  • Strength And Workability Properties Of Concrete

    replacement of sand as a major ingredient of concrete by quarry dust will be a techno economic solution to the above problem .The present research work was carried out to study . In this research the experimental investigations carried out in three phase M30 mix grade concrete is used with quarry dust in proportions of . slump values when .

  • An Experimental Study On Partial Replacement Of Sand

    Cost analysis shows that there is 40 savings if quarry dust is used instead of sand. Illangoan.R1 2000 has done a study on100 replacement of sand by quarry dust in concrete. The compressive strength of concrete with quarry dust has 40more strength than that of the concrete with sand. M. Shukla and A K Sachan2 2000 studied

  • Study Of Partial Replacement Of Fine

    Based on the experimental investigation concerning compressive strength and split tensile strength of concrete with quarry dust as a partial replacement of fine a ggregate the following conclusion can be drawn 1. The compressive strength of concrete is i use of quarry dust up to 10 replacement of sand

  • Citeseerx Use Of Quarry Dust To Replace Sand In Concrete

    Abstract- This experimental study presents the variation in the strength of concrete when replacing sand by quarry dust from 0 to 100 in steps of 10. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature.

  • Effect Of Fly Ash And Quarry Dust As A Partial

    by utilization of quarry dust which can be called as manufactured sand. Hence an attempt has been made to study the effect of partial replacement of fine aggregates by

  • Experimental Investigation On Self Compacting Concrete

    Abstract. Abstract This study presents an experimental investigation on self-compacting concrete SCC with fine aggregate sand replacement of a Quarry Dust QD 0 25 50 75 100 and addition of mineral admixtures like Fly Ash FA and Silica Fume SF amp chemical admixtures like super plasticizers SP.

  • Study Of Concrete Involving Use Of Quarry Dust As

    presented in TABLE 1. Fig.1 shows sieved quarry dust and Fig.2 shows manual mixing of quarry dust with sand. III. EXPERIMENTAL INVESTIGATION 3.1. Mix Proportion The concrete mix design was proposed by using IS 10262 10. The grade of concrete used was M-25 with water to

  • Strength Properties Of Concrete With Partial

    The research work carried out included an experimental investigation on strength properties of concrete made with 2.5 to 20 replacement of cement by quarry dust of less than 75 micron particle size. The tests were carried out to find the compressive strength splitting tensile strength and flexural

  • Pdf Experimental Investigation On Concrete With Granite

    an experimental investigation on utilization of ground granulated blast furnace slag and waste foundry sand as a partial replacement in concrete By IJEETE Journals IJERT-Experimental Study on the Properties of Concrete with Replacement of Cement by Quarry Sludge

  • Stone Dust In Concrete Effect On Compressive Strength

    Use of stone dust in concrete not only improve the quality of concrete but also conserve the natural river sand for future generations. In the present investigation an experimental program was carried out to study the workability and compressive strength of concrete made using stone dust as partial replacement of fine aggregate in the range of 10 - 100.